Product ID:BLACK IMPLEMENT ENAMEL
MSDS Date:01/10/1992
FSC:8010
NIIN:00F032660
MSDS Number: BSZYP

CEDARAPIDS INC SUB OF RAYTHEON CO

916 16TH ST NE
CEDAR RAPIDS, IA 52402-4602
US

Emergency Phone: 319-363-3511

Info Phone: 319-363-3511

Cage: EO694

IOWA PAINT MFG CO INC

DES MOINES, IA 50305-5000 US

Telephone: 515-283-1501

Cage: 4N775

STODDARD SOLVENT (PETROLEUM DISTILLATE), MINERAL SPIRITS

CAS: 8052-41-3

RTECS: WJ8925000

Fraction By Weight: 4.96%

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM

NAPHTHA PETROLEUM, HEAVY ALKYLATE C9-C12 BOILING PT

CAS: 64741-65-7

Fraction By Weight: 56.34%

SOLVENT NAPHTHA, PETROLEUM, LIGHT AROMATIC, HIGH FLASH

CAS: 64742-95-6

RTECS: WF3400000

Fraction By Weight: 1.59%

COLUMBIA CARBON, CARBON BLACK, LAMPBLACK, BLACK PEARLS

CAS: 1333-86-4

RTECS: FF5800000

Fraction By Weight: 2.01%

OSHA PEL 3.5 MG/CUM

ACGIH TLV: 3.5 MG/CUM

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHALATION: IRRITATION OF RESPIRATORY
TRACT. INJURY TO LIVER, KIDNEY, BONE MARROW & BLOOD CELLS. SKIN:
DERMATITIS & DEFATTING OF SKIN TISSUE. INGESTION: IRRITATION OF
MUCOUS MEMBRANES & GASTROINTESTIN AL TRACT & MAY CAUSE LIVER,
KIDNEY.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: HEADACHE, DIZZINESS, STAGGERING
GAIT, CONFUSION, UNCONSCIOUNESS OR COMA, PERMANENT BRAIN & NERVOUS
SYSTEM DAMAGE. EYES: REDDNESS OR SWELLING. INGESTION: CENTRAL
NERVOUS SYSTEM DAMAGE. CONV USIONS DELIRIUM, COMA OR DEATH.

First Aid:INHALATION: REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP
WARM & QUIET. EYES: FLUSH W/PLENTY OF WATER FOR 15 MINS. SKIN: WASH
AFFECTED W/SOAP & WATER. REMOVE CONTAMINATED CLOTHING. INGESTION:
IF SWAL LOWED, DON'T INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN
ALL CASES.

Flash Point Method:TCC
Flash Point:103-113F
Lower Limits:.9%
Extinguishing Media:USE NATIONAL FIRE PROTECTION ASSOCIATION (NFPA)
CLASS B EXTINGUISHERS (CO2/DRY CHEMICAL/FOAM) DESIGNED TO (SEE
SUPP)
Fire Fighting Procedures:DON'T USE WATER EXCEPT FOR COOLING CLOSED
CONTAINERS TO PREVENT PRESSURE BUILD UP & EXPLOSION WHEN EXPOSED TO
EXTEME HEAT. DON'T APPLY TO VERY HOT SURFACES.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT, NON-EXPLOSION PROOF ELECTRICAL EQUIPMENT, SPARKS & OPEN
FLAME. CLOSED CONTAINER MAY EXPLODE WHEN EXPOSED SUPP

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION (FLAMES, HOT
SURFACES & ELECTRIAL, STATIC/FRICTIONAL SPARKS). AVOID BREATHING
VAPORS. VENTILATE AREA. REMOVE W/INERT ABSORBENT & NON-SPARKING
TOOLS.

Handling and Storage Precautions:DON'T STORE ABOVE 120F. STORE LARGE
QUANTITIES IN BUILDINGS DESIGNED & PROTECTED FOR STORAGE OF NFPA.
CLASS II, COMBUSTIBLE LIQUIDS.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. DON'T TAKE INTERNALLY.
CONTAINERS SHOULD BE GROUNDED WHEN POURING. AVOID FREE FALL OF
LIQUID IN EXCEED OF A FEW INCHES. NEVER CUT, BRAZE/WELD EMPTY PAINT
CONTAINERS OR P AINTED SURFACES BEFORE THOROUGHLY DRY.

Respiratory Protection:IN OUTDOOR OR OPEN AREAS, USE NIOSH/MSHA
APPROVED MECHANICAL FILTER RESPIRATOR. IN RESTRICTED VENTILATION
AREAS USE NIOSH/MSHA APPROVE CHEMICAL MECHANICAL FILTERS. IN
CONFINED AREAS USE NIOSH/MSHA APP ROVED AIR LINE TYPE RESPIRATOR OR
HOODS.
Ventilation:PROVIDE GENERAL DILUTION/LOCAL EXHAUST VENTILATION IN
VOLUME & PATTERN TO KEEP TLV OF MOST HAZARDOUS INGREDIENT.
Protective Gloves:REQUIRED
Eye Protection:SAFETY EYEWEAR
Supplemental Safety and Health
CONT' ON EXTINGUISHING MEDIA: EXTINGUISH NFPA CLASS II LIQUID FIRES.
CONT' ON SPECIAL FIRE: W/MASKS & SELF CONTAINED RESPIRATORS.

Boiling Pt:B.P. Text:307-406F
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:62.90

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS SUCH AS PORMANGANATE.
Stability Condition to Avoid:EXTREME HEAT.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.